NI 9205现货 in stock! 欢迎来电咨询~！！

NI 9205,

NI 9205

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

数控编程工艺及加工效率的研究

由于后控板塑件在洗衣机上为外观件，表面光洁度要求较高，所以在模具型腔加工制造过程中必须保证型腔尺寸的公差要求和表面粗糙度要求。对于该模具型腔零件，从内向外主要由以下几部分构成：塑件型腔面、分型面、排气槽、侧抽芯槽、模架面、回程杆垫片槽等。在编制数控编程工艺时，一般按照整体粗加工、分型面半精加工、分型面精加工、型腔面半精加工、型腔面精加工、型腔局部形状清角的工艺思路进行编程，并按照分区域编程的思路，逐渐完成整体零件的编程工作。



图1 洗衣机后控板模具型腔

2.1 整体粗加工刀具的选择

在编制粗加工程序时，粗加工刀具型号的选择直接决定了开粗的加工效率。若开粗刀具选择过小，致使每刀的下刀量较小，而且刀具的进给速度也较小，最终导致工件的加工效率很低。若开粗刀具选择过大，表面上看起来粗加工时间很少，但是开粗效果不理想，本应开粗到位的区域没有开粗到位，需要增加整体中粗程序或大范围的清角程序，这样总体的加工时间也会增加。所以在粗加工刀具选择方面，不但要考虑到工件的整体尺寸大小，还要考虑该零件的材料去除量大小。对于中小型零件来说，原则上把开粗时间 控 制 在 5h 以 内 ，初 步 选 定 开 粗 刀 具 为 直 径 为 32mm的牛鼻刀，刀具定义为D32R0.8mm。
2.2 型腔精加工刀具的选择

在对模具零件型腔进行精加工时，由于模具的型腔面在塑件上为外观面，表面光洁度要求较高，并考虑到模具的型腔面大部分为曲面，所以在精加工刀具选择方面，优先选择球头铣刀进行加工，刀具符号用B及 R 表 示 ，如 直 径 为 20mm 的 球 头 刀 定 义 为B20R10mm。本次研究列出了 3 种精加工刀具选择方案：第 1种方案为大直径球头铣刀（B16R8mm）整体精加工、小直径球头铣刀（B8R4mm）局部清角的编程加工工艺；第 2 种方案为较大直径球头铣刀（B12R6mm）整体光刀、小直径球头铣刀（B8R4mm）清角的编程加工工艺；第3种方案为整体用小直径球头（B8R4mm）刀一次加工到位，如表 1 所示。然后对以下
 

RSI Software Products 9356-PRO2500U4 UPGRADE: IN-SUPT: RSSQL STD.UNLIMITED TO 70000 TAG

Motion Control 1326AB-B520F-M2L MOTOR,SERVO,460V,13.1NM,3500RPM,MULTI,IP67

Silver Series 1398-DDM-005 DRIVE,7.5A PEAK, ULTRA 100

CBL-204 Mitsubishi FX Cable

HMI-COV-201 FRONT SHEET COVER FOR 9"

IC647WMI320 Workstation Interface (WSI) for PS/2, Series 90 Serial

IC800SSD216RS1 16A, 230V, S2K Servo Drive for MTR Series Motors

MTR-1231-E-D-E-0 MTR series NEMA 23 stepping motor with encoder. Winding connection type is determined by cable

Z44A730464-G20 Motor power right angle connector for AC12/2000 or AC12/3000 or A12/3000 or A22/2000 or B22/2000is motor

20BD077A3ANNANC0 PowerFlex 700 AC Drive 77 A 60 Hp 20B

20G11NC037JA0NNNNN PowerFlex 755 AC Packaged Drive

22F-B8P0N103 PowerFlex 4M- 1.5 kW (2 HP) AC Drive

990NAA21510 Quantum RUGGEDIZED MBUS+ TAP PROG

294D-FD1P5Z-G1 Variable Frequency Drive

S82Y-05N 电源安装支架，（导轨用）适用S82J

1492-SPM3B010-N MCB Supplementary Protector 1 A

软启动器 3RW40241BB05

电机启动器 3VU16402CL00

150-F43NBD SMC Flex Smart Motor Controller

1734-8CFG POINT I/O 8 Point Combination Module

1774-XD 2 (3POS) PROCESSOR KEYS

193-EF1BKP EF 160-400 A IEC Overload Relay

20-750-BUS3-F9 PF755 FR9, IP00, OUTPUT TERMINATION KIT

2090-CPWM7DF-10AA40 MP-Series 40m Servo Power Cable

2097-V33PR5 Kinetix 300 Servo Drive

ET-GT-5ES-4SC 3 RJ45 Ports, 2 Multimode Fiber Port Ethernet Switch

GFK-2055 VMIC

IC220MDL643 INPUT, 24VDC POSITIVE LOGIC, 8PT (REQUIRES 4 IC220TBK082)

IC647DMC003 DataMart 3 Reporting Clients

IC647PWR003 Proficy Power SCADA for Large Control Room

IC693MDL241RR 24 Vac/Vdc Input (16 Points)

IC756CDV001J-97 DV Development - Compaq True64 Op Sys Addt'l User, Japanese, Version 9 .7

MSI-PROD-10-43 Product Mang Clients 10 Pack-43

PLC-5/1771 System 1785-L80E ETHERNET/IP PLC-5/80 CONTROLLER, 100K WORD SRAM

Distributed I/O 1738-EP24DC 24 V DC POWER EXTENSION

Communications 1784-PCIC CONTROLNET PCI BUS MESSAGING CARD WITH

Operator Interface 2711E-NF1 FUNCTION KEY LEGEND INSERTS, PV1000E KEYPAD

Support 9304-WVR128S SUPT RENEWAL CONTRACT FOR 9304WVR128

Support 9324-RLD25U7ITE RSLOGIX 5000 LITE ITALIAN TO PRO UPGRADE

DeviceNet Products 2711-T6C10L1 PV600 COLOR TOUCH, DNET & RS232 PRINT

RSI Software Products 9301-2SE3400DEU1 RSVIEW32 RUNTIME 1500-32K UPGRADE IN-SUPT (DE)

RSI Software Products 9371-EDETJAC RSWIRE DETAILER/JIC FOR AUTOCAD 14-14.01

Motion Control MPF-A430H-MJ24BA MOTOR,SERVO,FDGRADE,6.55NM,3500RPM,MULTI,BRK

2024 Greyline OS, 2 Line, (20) 5MM Chars, LCD, Quick Connect, NEMA 4

HE693THM166 16 ch. J, K, N, T, E, R, S, B, C 0.5 癈 resolution, 癈/癋 units, 16 alarms

IC670MDL644 24VDC Pos./Neg. Logic Fast Input 16pt Grouped

QPJ-ABR-201 MODULE AB REMOTE I/O

STXPBS016 STXi Profibus with relay output, 16 points, expandable to 8 additional modules.

20BC2P1A3AYNANC0 PowerFlex 700 AC Drive 20B

20F1ANC456JA0NNNNN PowerFlex 753 AC Packaged Drive

22B-B5P0N104 PowerFlex 40- 0.75 kW (1 HP) AC Drive

140DDO35300C Quantum 开关量DC输出,32点,24VDC,4组隔离,0.5A/点,

284D-FVD7P6Z-25-CR-3-DB-SB-EMI DeviceNet Variable Frequency Drive

E3X-A11 光纤放大器, 晶体管输出 NPN 80mA, 电源:12-30VDC

1492-SPM1B100-N MCB Supplementary Protector 10 A

直流电源 6EP1331-1SH02 120/230VAC 输入，24VDC/1.3A 输出

6ES78221AA000YM5

1497D-A12-M10-0-N Gen Purpose Transformer

1606-XLSBATBR2 1606 Power Supply

1769-L24ER-QBFC1B CompactLogix 750KB DI/O AI/O Controller

190E-AND2-CB40X 2.5-4.0 A Economy Starter W/Ckt-Bkr

194R-J60-1753-PYS1 194R Disconnect Switch

2090-CPBM7DF-14AF12 MP-Series 12m Continuous-Flex Cable

2090-XXNPT-16S09 Kinetix Drives 09m Standard Cable

CBL-3T-MP-20 Power cable for MTR-3T50 or MTR-3T60 series servo motors. 20 feet

GF-0912R/FOW Connecting FlashCable to Fowler Sylvac, Metronics, Mettler, Omega, Tol edo (FOW).

IC200UAL006-24 Qty of 24, 23 point PLC< (13) 24VDC In, (9) Relay Out, (1) 24VDC Out, (2) Analog In & (1) Analog Out, 120V/240AC Power Supply. Battery (IC2 00ACC403) is required for dtat retention. Battery not included.

IC646TDV300 300 I/O Point Development System

IC647NWV050 CIMPLICITY HMI WebView 50 User

IC693ALG223 Analog Input, Current, 16 Single Channels

IC752CTD400RR Display Station - 9.5 inch active matrix VGA (640x480) infrared touch scre en/ 16 color support/ Pentium 133/ 32M/ 1.2 Gig hard driv e/ expansion slots/ Ethernet/ with CIMPLCITY HMI and Win 95

IC800VMM20LBKSE25 2 kW VersaMotion servo motor with 24 VDC holding brake (6.37 Nm)

SLC/1746 System 1746-HSRV SLC SERVO

Industrial Computers 6189V-RACKSLIDES 1400R RACKSLIDES

Application-specific products 1403-NDNET COMMUNICATION MODULE (DEVICENET)

Operator Interface 2711-K6C3L1 PV600 COLOR KEY, DH485 & RS232 PRINT

Support 9301-2SE2500PTR SUPT REINSTATEMENT CONTRACT FOR 93012SE2500PT

Support 9380-RSB5000S SUPT RENEWAL CONTRACT FOR 9380RSB5000

DeviceNet Products 1734-IJ 5 VDC INCREMENTAL ENCODER MODULE

RSI Software Products 9301-2SE3200DEE RSVIEW32 RUNTIME 300 (GERMAN)

RSI Software Products 9358-BPC60U1 UPGRADE: IN-SUPT: RSBIZWARE PC PHASES 03 TO 60

Motion Control MPL-B430P-RJ22AA MOTOR,SERVO,6.55 NM,5000RPM,RSLVR,460V,7.3KG

Motion Control 2090-SCEP3-0 SERCOS FBR CABL,CONN,ENCLOSURE ONLY PLASTIC,3.0M

GFK-1055 Plug & Play PC Coprocessor for Series 90-70 PLC User's Manual

IC646MDC700 Logic Developer - PC & View 700 Tag Runtime & Development System

MSP-CUR-IN2 Obsolete - 0-20 mA in / Pulse out

QPI-ABD-201 Communication Module for 7 inch/ 9 inch/ 10 inch & 12 inch: AB DataHighway Plus/ UL/ c UL/ CE/ UL1604

20BC022A3AYNANC0 PowerFlex 700 AC Drive 22 A at 11 kW 20B

20F11GC8P7JA0NNNNN PowerFlex 753 AC Packaged Drive

21G14PC770JN2NNNNN-ND-P20 PowerFlex Air Cooled 755 Packaged Drive

2711P-RDT10C PanelView Plus Display Module

280D-FN-10-R ArmorStart Direct Online Starter

C200HG-CPU43-E CPU单元? 内存15.2K最大I/O点数：880点?带RS-232C时钟

1492-PBC8 Power Distribution Block Accessory

中央机架 6ES7400-1TA01-0AA0 UR1 机架 用于中央控制器和扩展单元,18 槽

变送器 3RS18002HP00

TIA 博途 WinCC 选件 6AV2107-4GX00-0BF0 SIMATIC WinCC Logging Upgrade for SIMATIC WinCC Archives V7.0 (10 licenses)

1585J-M8PBJM-5 RJ45 Ethernet Media

1760-MM1 Pico 12 Point Memory Module

188-K2D130 Miniature Circuit Breaker 13 A

194L-E12-3261 12A 194L Load Switch

2090-CNSSPSS-AA05 Kinetix 6000M network cable

2090-XXLF-TC316 Kinetix 2000 Line Filter

BC647OEM0111 OEM Edge Program Renewal Additional Key - iFIX

GC647IPWRSTRN00900M iPower Option - Std 900 I/O Run Globalcare Complete part

IC200ERM001 Expansion receiver isolated

IC646NGM000 Honeywell IPC620 Communications

IC647IGSSNMP IGS - IGS SNMP Driver

IC670MDL643 5/12Vdc Pos./Neg. Logic Input, 16 Point, Grouped

IC697MDL341 120/240 Vac Isolated Output, 2 Amp (12 Points)

IC800SLCIV030 Interface cable to connect any 1 kW to 5 kW SL series amplifier to terminal block. 3 meters

ControlLogix/1756 System 1756-TC15 1756 ETHERNET INTERFACE TRANSCEIVER CABLE 15 METER

Industrial Computers 6182H-12TEH15D VVCE 1250, TOUCH, EXT MEM, CNET, DC

Process Control 1757-PFBUL080 PROFIBUS INTERFACE MODULE USAGE LICENSE

Operator Interface 2711P-RUL50 PANELVIEW PLUS FIRMWARE UPGRADE LICENSE

Support 9357-DNETMDAD3R SUPT REINSTATEMENT CONTRACT FOR 9357DNETMDAD3E

Support 9362-WORKBENCHS SUPT RENEWAL CONTRACT FOR 9362WORKBENCH

ControlNet Products 1734-OE2V 24V DC 2 CHANNEL ANALOG VOLTAGE OUTPUT MODULE

RSI Software Products 9301-2SE2403JPE RSVIEW32 WORKS 32K WITH RSLINX (JAPANESE)

RSI Software Products 9358-B10ENE RSBIZWARE BATCH 10 UNITS

Motion Control MPL-A430H-MJ22AA MOTOR,SERVO,6.55 NM,3500RPM,MULTI,230V,6.4KG

Motion Control 2090-UXNFBN-S15 CABLE,ULGRF50ON-FLEX,MOTOR FEEDBACK,N,15M

CBL-148 Cable.OMRON Host link Unit CQM1 (RS-232)

IC610MDL103RR 24Vdc Sink Input/Output (4 In/4 Out)

IC800SLA0402 400W, 230 VAC SL Servo Amplifier

OC647IFGLBLCLN020M iFIX WebSpace 20 Additional Users (M4 key)

20AD2P1A3AYYANC0 PowerFlex 70 AC Drive 2.1 A at 1 Hp 20A

20DD011A0EYNANBNE PowerFlex 700S AC Drive 20D

20P21AD996RA0NNN PowerFlex DC Drive 996 A

2711-NM15 PanelView Accessory

280-PWRM22H-M14 ArmorStart Three-Phase Power Media

3G3JV-A4022 5.9KVA 5.5A 2.2KW 三相AC380-460V/50HZ/60HZ

1492-MCAA215 15 A UL489 Miniature Circuit Breaker

1494U-LA100 1494U 100A Aluminum Lugs

软启动器 3RW44552BC35

Safety Advanced V14 6ES7833-1FA14-0YJ5 STEP 7 Safety Adv.V14SP1 Powerpack SW DL

1585D-M4UBDM-40 1585D Ethernet Media Patchcord

1756-IT16 ControlLogix 16 Pt TC Input Module

1797-OE8 FlexEx 8 Point Analog Output Module

194E-E40-1756 40 A 194E Load switch

2090-CFBM6DD-CCAA03 TL-Series 3m Feedback Cable

2090-S-BLHD Kinetix Fiber Optic Bulkhead Adaptor

BC646MDA150 View Development/Runtime 150 I/O with Proficy GlobalCare Complete

GC647ACL001 GC Redundant Key

HMI-CAB-C119 CABLE GE FANUC VERSAMAX MICRO/NANO, RJ45 Serial Port

IC641SWP041 Series 90 Protocol (SNP) Driver, Source, Multi-Use License

IC647IFCLNTSRO001C iFIX iClientTS Read Only 1 PK (M1Component Part)

IC660EBA104RR Current Source Analog, 115Vac, Electronic Assembly

IC695PSA040CA RX3i AC Power Supply, 40 Watt Conformal Coated

IC756WRE049K-23 DataViews Runtime for Windows 25-49, Per User, Korean, Version 2.3

FlexLogix System 1794-OA16 85-132V AC OUTPUT MODULE, 16 POINT

PLC-5/1771 System D1785-6.2.1 1785 PLC5 PROGRAM. CONTROLLERS DESIGN MANUAL

Process Control 1757-PLXSIFP PLX MOORE 351,352,353,383 QUICKBUILDER INTERFACE

Operator Interface 2711P-B10C6D2 PV PLUS 1000, KEY/TOUCH, RIO/DH, DC PS, EXT MEM

Support 9310-WE0200R SUPT REINSTATEMENT CONTRACT FOR 9310WE0200

Support 2706-LSWS SUPT RENEWAL CONTRACT FOR 2706LSW

Support F1785-L40BSERD FIRMWARE UPGRADE FOR 1785-L40B PLC5 PROCESSOR MODU

RSI Software Products 9301-2SE2300KOU2 RSVIEW32 WORKS 150-1500 UPGRADE IN-SUPT (KO)

RSI Software Products 9701-VWSCRADEE RSVIEW SE VIEW CLIENT (GERMAN)

RSI Software Products 9399-PLTMGR RSBIZWARE PLANTMETRICS GETTING RESULTS GUIDE

Motion Control 2098-DSD-HV050-SE HIGH VOLTAGE DRIVE, 11A/22A, ULTRA3000 W/SERCOS

BC646MDC000 Logic Developer - PC & View Development/Runtime 8,000 I/O

IC300MIX905 8 DC Inputs (12/24vdc), 6 Relay Outputs (3.0A ea), 4 Analog Inputs (o-20mA, 0-5v, thermister), 2 Analog Outputs (o-20mA, 0-10v)

IC752SKT004RR Datapanel 320T MB Starter Kit: Includes Datapanel 320T Mono Base (CBT000), download & communication cables, WinCfg, user & programming manuals

MTR-3S86-G-R-0-E-SRR Servo Motor with Seal

ZA06B-6124-H105 Alpha SVM1-80HVi FSSB 80 amp amplifier

20CC385A0ANNBNN0 PowerFlex 700H AC Drive 20C

20G1ABF330JN0NNNNN PowerFlex 755 AC Packaged Drive

25A-D1P4N114 PowerFlex 523 0.4kW (0.5Hp) AC Drive

2711P-T6C20D8 PanelView Plus 6 6 Color Touch DC

6SE6440-2UD24-0BA1 4KW

1492-JTC3T IEC 2-Ckt Thermocouple Blk,Type T,2.5mm

1492-XIM20120-16RF Connection Products

软启动器 3RW44241BC46

通信模块 6GK7 542-5DX00-0XE0 CM 1542-5：RS485，PROFIBUS 通讯模块

1585-C8CB-S100 Cable Spool Ethernet Media

1746-OW8 SLC 8 Point Digital Output Module

1790-15CMCBL CompactBlock LDX Expansion Cable

194E-A-PL11 194E 1 No-1 Nc L.B. Aux. Contact Block

20-PP09055 XFMR INVERTER FAN- USE 20-FR09154 TO MNT

2090-CSBM1DF-18AA09 Kinetix Cable Single DSL 2090-Series

20AC037A0NYNACC0 PowerFlex 70 AC Drive 20A

GC-8459-SS-MT Sales System Workbench (unlimited license -- internal use only)

HE300GEN100 Genius Communications Interface for GE AF-300E$ Adjustable Freq. Drive s

IC600KD514RR Color OptiBasic Operator Interface Terminal/ 12 inch CRT

IC647HSTES1750KM Historian Enterprise Server 1,750,000 Points (M4 Key)

IC648MNT039 Annual Software Maintenance for LM90-30 Win 95/NT Ethernet

IC694ALG442 Analog combination module current/voltage 4 inputs 2 outputs.

IC756SDV000J-97 DV Development - Solaris Op Sys, Japanese, Version 9.7

MicroLogix 1200 System D1762-UM001BENP MICROLOGIX 1200 PROG. CONTROLLER USER MAN.

PLC-5/1771 System 1771-WA FIELD WIRING ARM, 10 TERMINALS, TIN PLATED

Distributed I/O 1794-IE8K CONFORMAL COATED, ANALOG INPUT MODULE, 8 POINT

Communications 9399-WAB32LUGDE RSLINX LITE USER GUIDE (GERMAN)

Support 6223-52VDLS SUPT RENEWAL CONTRACT FOR 622352VDL

Support 9358-BPC03S SUPT RENEWAL CONTRACT FOR 9358BPCNT03ENE

Support F1771-ILSERA FIRMWARE UPGRADE FOR 1771-IFE I/O MODULE

RSI Software Products 9324-RLD000ITE RSLOGIX 5000 SERVICE EDITION, ITA

RSI Software Products 9301-2SE350JPU3R RSVIEW32 RUNTIME 300-100K UPGRADE OUT-SUPT (JP)

RSI Software Products 9358-HSTS2500U2R UPGRADE: OUT-SUPT: HISTORIAN 300 TO 70K TAG

Motion Control 8720SM-015S2EBS4 15 KW/41.5 AMP, 460 VAC, MOTOR WITH SNS60,+MPL

829-1-1 Thumbwheel Assembly. 1 Digit, 1 True. Dust Seal

IC200MDL329 OUTPUT 120VAC 0.5A PER PT ISOLATED 8PT

IC697CMM798RR Replacement Part, MAP 30 Controller, Broadband

MTR-1324-E-D-E-0 MTR series NEMA 34 stepping motor with series winding connection and encoder

Z44C742238-004 Replaced by CB1N-1WPM-0140-AZ

20BD096A3AYNACC0 PowerFlex 700 AC Drive 96 A 75 Hp 20B

20G11NC3P5JA0NNNNN PowerFlex 755 AC Packaged Drive

22F-D6P0N113 PowerFlex 4M-2.2 kW (3 HP) AC Drive

NWRR85001 Quantum REPEATER ASSY

294D-FD4P2Z-G2 Variable Frequency Drive

S8VS-06024 NEW 100-240VAC,容量：60W输出 2.5A 导轨安装型

1492-SPM3B080-N MCB Supplementary Protector 8 A

软启动器 3RW40271TB04

电机启动器 3VU16403CQ00

150-F60NBDD SMC Flex Smart Motor Controller

1734-FPD POINT I/O Field Distributor Module

1783-BMS10CGP Stratix 5700 10 Port Managed Switch

193-EIOGP-22-120 E300/E200 120V AC Control Module

20-750-DB1-D1A Frame 1 DB Resistor, 115 Ohms, 1.0 to 3.

2090-CPWM7DF-10AF50 MP-Series 50 m Length Power Cable

2098-DSD-005X-DN Ultra 3000 0.5kW with DeviceNet Drive

FG-FF Proficy Process Systems Fieldbus Linking Device from Softing

GFK-2078 IC697VAL306, 12-bit Analog Output Board User's Manual

IC220PWR002 POWER TERMINAL, FUSED 24VDC (REQUIRES 1 IC220TBK087)

IC647DMS025 DataMart 25 PA Connections

IC647ROC050C ROC:Fisher Remote Operations Controller for 250 Units

IC693MDL390LT 120/240 Vac Isolated Output, 2 Amp (5 Points) (LT)

IC756CDV010K-98 DV Draw Development on Compaq True64, Korean, Version 9.8

MSI-PROD-SV-43 Product Mang Server Software-43

PLC-5/1771 System 1785-CHBM CONTROLNET 1.5 HOT BACKUP MEMORY CARTRIDGE

Distributed I/O 1790-T0W8X LDX I/O, 24VDC, 8 RELAY OUT EXPANSION, TERM BLK